PRC Polaris Ranger Club banner

Search results

1-20 of 200 Results
  1. 2005 Ranger 700 engine stalls when throttle applied

    Ranger Technical
    Sounds like the ECM aka power module is taking a final krap.......... Module Masters can rebuild and warranty for 5 years.......for half of a new one. But yeah, check the harness and the CPS.....first
  2. 2005 Ranger 700 engine stalls when throttle applied

    Ranger Technical
    Also Brian, have you checked the Crank Position Sensor ? Right side rear of engine. Normally it is the harness that is bad and early on the engine will start hard and falter before finally not firing at all. I know you said you have a new harness but you will want to pull the CP sensor out and...
  3. 2005 Ranger 700 engine stalls when throttle applied

    Ranger Technical
    That is a lot of new ! So if everything is new (gas, sensors, harnesses) and the FP is perfect and the settings are perfect and the ECM is perfect ..................that leaves the injectors,coils or the power module. The injectors are hard to screw up unless you really worked at it. I have...
  4. 2005 Ranger 700 engine stalls when throttle applied

    Ranger Technical
    Your welcome Brig. I can't help you anymore though because you keep ignoring my request for pertinent information. Kind of a waste of my time when so much secret info is not shared
  5. Stuck in 4x4 ?

    Ranger Discussions
    That is a cracked and jambed roll cage in the front gear case. When it does that 'drag thing', stop and back up about 20-30 feet and see what happens. Either way, I think pulling the front gear case and installing a new cage is in your near future.
  6. Code 41 and 45 Problem

    Ranger Problems & Solutions
    O, you absolutely need to change the TBAP harness to a REAL one or you are going to end up stranded. GUARANTEED ! After you change that out, check your fuel pressure 39 psi +/- 3 . Once those are good, you will be good to go.. https://otbpowersports.com/product/t-bap-wiring-repair-harness/
  7. Stuck in 4x4 ?

    Ranger Discussions
    "In high or low it gets up to about 25mph and you smell belt, in the gravel it leaves tracks from all 4 tires, " Pretty strange Delmo, If you are in 1/WD and it is truly spinning all four wheels, the roll (SPRAGUE) cage in the front gear case is busted and the turf mode actuator in the rear is...
  8. Rats!!

    General Member Discussions
    If the perfumey odor doesnt keep them away they will will have the softest nest in the neighborhood. :)
  9. Miles in a used ranger xp

    Ranger Discussions
    w, if you have not replaced the front drive hubs, the previous owner surely has. Reach under the front and grab an axle and give it a shake and look for movement at the gearcase. You have to catch them and grind the a-arm tabs before they rip the boots.
  10. Miles in a used ranger xp

    Ranger Discussions
    Mo, that is not a ton of miles but on a 2009 that is enough to smoke the lower steering shaft u-joint, use up the suspension bushings, a bit of wear on the drive hubs in the front gear case and front driveshaft u-joints . I would ask the owner if he has replaced any of things mentioned above...
  11. 2015 570 efi diagnostic code help

    Ranger Discussions
    Heres your repair harness..........My crystal balz are ringing and shouting "change the harness ! https://otbpowersports.com/product/polaris-throttle-body-motor-repair-harness/ Make it so...........
  12. 2015 570 efi diagnostic code help

    Ranger Discussions
    Could be a defective throttle body then if the wiring is good..............I would think it is a bad wire. How did you check the wires ?
  13. 2015 570 efi diagnostic code help

    Ranger Discussions
    Check the harness and connection going to the TB .Pull it apart and grease it. These skimpy wired muthas are fickle.
  14. 2015 570 efi diagnostic code help

    Ranger Discussions
    Toxic 21 may know ........ TOXIC !!! what do you think? I would start by disconnecting the negative cable for 30 seconds from the battery for a reset and see if it goes away..
  15. Check your 570 full size crankcase vent hose

    Ranger Technical
    POCO has made MILLION for over a decade selling known defective sensor harnesses, throttle body adapters, heat shields and now vent hoses. Not only the replacement of these smaller ticket items, but then the real money comes in with the replacement of the cylinders & pistons etc that are...
  16. Air filter issues leads to big bill

    Ranger Discussions
    Thanks !
  17. 2015 570 efi diagnostic code help

    Ranger Discussions
    1520277 & 0520284 are both throttle body codes.
  18. Starts and Runs fine then shuts down No Hot Engine Light and Irregular Fan activity.

    Ranger Technical
    KW , I am done responding to your posts..........I recommend you CALL MODULE MASTERS and keep your di%k beaters off of everything else to avoid causing yourself further complications.........
  19. Starts and Runs fine then shuts down No Hot Engine Light and Irregular Fan activity.

    Ranger Technical
    The modules often times have NO pin damage on the outside but the PCB inside can be toast. Unfortunately, no way to test them other than to install a known working one. If you call and talk to the tech at MODULE MASTERS, and intelligently explain your symptoms, he can put your mind to...
  20. Starts and Runs fine then shuts down No Hot Engine Light and Irregular Fan activity.

    Ranger Technical
    Don't be a puzzy...besides, riding it and throwing ice water on the fuel pump is not going to power the fan. That is a Ranger.nit idiotic waste of time . AT LEAST pull the connectors off the power module and check for fried pins and CALL that number to MODULE MASTERS and talk to them about...
1-20 of 200 Results
Top